Select a Country or Region

waste oil distillation machine
waste oil distillation plant
waste oil distillation plant
waste oil distillation machine
waste oil distillation machine
waste oil distillation plant
waste oil distillation plant
waste oil distillation machine

New Type Waste Oil Distillation Plant for Recycling Mixture oil to Yellow Oil

Waste Oil Distillation Plant to recycle waste oil into a base oil. Vacuum distillation is a method of distillation that the pressure above the liquid mixture to be distilled is reduced to less than its vapor pressure (usually less than atmospheric pressure), causing evaporation of the most volatile liquids (those with the lowest boiling points).  As with distillation, this technique separates compounds based on differences in boiling points. In general, water and dissolved low boiling point organic removed by atmospheric or moderate vacuum distillation. Lube oil is then recovered and fractionated by distillation. Light ends by-products are commonly used for plant combustion fuels. Diesel and gasoline can be recovered as high-quality by-products after further advanced treatment. Residual streams from distillation can be used by the asphalt industry as an asphalt flux to produce roofing asphalt, paving asphalt, insulating materials, and other asphalt-based products.

Share to

Product Description:

YJ-TY series can recycle different kinds of waste oil to clean Yellow Base Oil, like SN150, SN200, SN300.

 

What kinds of waste oil can be recycled by YJ-TY Waste Oil Distillation Plant?

Gasoline motor oil, Diesel engine oil, Mineral oil, Synthetic oil, Industrial lube oil, transmission oil,  hydraulic oil, gear oil and mixture oil.

 

The Importance of Recycling Used Oil:

Used oil is definitely a vital source of energy. Oil doesn`t wear out, it just gets dirty after use. Used oil still has lubricating value and heat value. Thus, Used oil can be re-refined into base lube oil, reprocessed as fuel oil, or used to as feedstock to produce products or other commercially valuable products via different methods. There are some facts about conserving resources through proper handling of used oil. Collecting and recycling used oil, therefore, not only protects our environment form used oil contamination, but also conserves a valuable non-renewable resource.

 

What's the base oil?

The biggest part of a lubricant is composed of base oils while the remaining part is oil additives which help to protect your engine against wear and corrosion and keep it clean.70% of a lubricant is composed of base oils while the remaining 30% are oil additives which help to keep your engine cool, clean, and corrosion-free. so we can add oil additives into the base oil to produce new hydraulic oil, gear oil or engine oil, the oil additives including dispersants, Anti-wear, Oxidation inhibitors or viscosity index improver.

 

New Type Waste Oil Distillation Plant for Recycling Mixture oil to Yellow Oil

 

What technology do we use?

Yangjiang Company uses vacuum distillation technology to recycle waste oil into a base oil. Vacuum distillation is a method of distillation that the pressure above the liquid mixture to be distilled is reduced to less than its vapor pressure (usually less than atmospheric pressure), causing evaporation of the most volatile liquids (those with the lowest boiling points).  As with distillation, this technique separates compounds based on differences in boiling points. In general, water and dissolved low boiling point organic removed by atmospheric or moderate vacuum distillation. Lube oil is then recovered and fractionated by distillation. Light ends by-products are commonly used for plant combustion fuels. Diesel and gasoline can be recovered as high-quality by-products after further advanced treatment. Residual streams form distillation can be used by the asphalt industry as an asphalt flux to produce roofing asphalt, paving asphalt, insulating materials, and other asphalt-based products.

 

New Type Waste Oil Distillation Plant for Recycling Mixture oil to Yellow Oil

 

New Type Waste Oil Distillation Plant for Recycling Mixture oil to Yellow Oil

 

  1. First, pump the waste oil after pre-treatment into a chemical reactor, add the chemical solution. Keep mixing the oil inside the reaction kettle. In the reaction kettle make the oil static after mixing, we have the impurities and part of the colloid at the bottom of the reaction kettle separated. After this chemical catalyst treatment of oil, the oil will not be cracked even it is heated up to 400 degrees in the atmosphere. (in the atmosphere, without the treatment, the oil starts to be cracked at 300 degrees, it obviously declines the quality of recycled oil and recovery rate).
  2. After chemical treatment, the waste oil is heated by an electric heater, to control the oil temperature within 330 degrees. As the temperature of the waste oil rises to around 55℃, the first cut off gasoline starts to release from the waste oil. As the temperature of the oil rises to around 110°C - 220°°C, the second cut of diesel oil is released. Base Oil is the main product and its distillation starts at around 220°C and continues up to 330°C. The light base oil is distilled out around 220°C-300°C, and heavy base oil distills out during 300°C -330°C. Finally, the process ends when the residual material in the waste oil does not vaporize. At this point, the heating in the distillation process is stopped and the process is essentially complete. We can pump oil residual out to use as bitumen and heavy fuel oil.
  3. Yangjiang's machine was contain a heating system, the fuel is diesel oil, fuel consumption is about 13-18Liters diesel oil for recycling 1000Liters waste oil.

 

New Type Waste Oil Distillation Plant for Recycling Mixture oil to Yellow Oil

 

Recycled base oil parameter:

No. Item Unit Technical data
Light base oil Medium/heavy base oil
1 Viscosity40℃) mm2/s 16~32 28~72
2 Viscosity index   ≥99 110
3 Appearance   Transparency Transparency
4 Color index ASTMD 1500 Number ≤1 ≤2
5 Pour point -15 -10
6 Water content %W/W ≤0.05 ≤0.05
7 Flash pointopen ≥190 ≥225
8 Ash content %W/W 0.005 0.005
9 Carbon residue %W/W ≤0.13 ≤0.13
10 Corrosioncopper100℃,3h Qualified Qualified
11 Acidity mgKOH/g ≤0.05 ≤0.05
12 Demulsibility(54C) GB/T7305-2003 (2004) 5min 5min
13 Oxidation Resistance SH/T0193-2008 350MIN 350MIN
14 Density Kg/m3 837 850

 

Our Company:

Chongqing Yangjiang Machinery Manufacturing Co., Ltd. has unique technology and rich experience in the waste oil recycling industry, the company constantly seeks development, extensively absorbs the world's advanced oil purification technology, and is committed to research and development in the field of oil treatment. Yangjiang not Only engaged in waste oil equipment manufacturing, but also provides consulting services for the investment and management of waste oil recovery and oil refining projects, Yangjiang has a professional technical team composed of masters and doctors with rich experience in equipment design, providing customers with quality design services in waste oil recovery and oil refining projects, providing customers with engineering design products that meet international standards, national standards and industry standards, including preliminary design, construction drawing design, and software control design. We can provide high quality and advanced design services such as container and pipeline process simulation, 3D design, strength analysis, vibration analysis, safety analysis and software control. Based on project management, equipment design, procurement and rich modular manufacturing, testing, commissioning and after-sales service experience in oil processing, Chongqing Yangjiang Machinery is committed to providing customers with complete and efficient modular solutions to meet customer needs. Our machine was installed in many places in China market, such as Tianjin, Fujian, Taiwan, Inner Mongolia, Jiangxi, Guiyang, etc. and has exported to different countries, like Russia, Greece, Algeria, Liberia, South Africa, Equatorial Guinea, Malaysia, Indonesia, Bangladesh, Philippine, Mexico, Chile, Honduras, etc.

New Type Waste Oil Distillation Plant for Recycling Mixture oil to Yellow Oil

Yangjiang’s Oil distillation machine already installed at domestic, such as Guiyang, Tianjin(20Ton per day), Shandong, Fujian(50Ton per day), Jiangsu(30Ton), Inner Mongolia, Taiwan(30Ton per day), also has exported to different countries, like Russia(0.5Ton per day), Greece(20Ton per day), Algeria(10Ton per day), Liberia(4Ton per day),Sri Lanka(0.5Ton per day), Malaysia, Indonesia, Bangladesh, South Africa, Mexico, Colombia, Chile, Argentina, etc.

Warmly welcome to contact us to know more about our oil distillation plant and visit our factory at any time. Please feel free to let us know if there's any question in Business.  (+86 133 9980 7550 Whatsapp / WeChat 24-H service).